高硅含量硅丙乳液的性能研究

采用单体滴加法制备了高硅含量的硅丙乳液.用红外光谱对乳液涂膜性能进行了分析和表征.研究了乳化剂的配比和用量,电解质的用量以及油水比对乳液性能的影响.研究表明：非离子型乳化剂OP-10和阴离子型乳化剂十二烷基磺酸钠配比为2/1,用量为2.0%,电解质用量为0.5%,油水比为0.6,合成硅含量占丙烯酸酯单体总量40%的硅丙乳液,其各项性能符合国家标准GB/T20623-2006.     

掺固硫灰干粉砂浆的性能研究

对掺固硫灰干粉砂浆的性能进行了研究。讨论了固硫灰细度、掺量及与粉煤灰复掺对干粉砂浆工作性能、力学性能和膨胀性的影响。结果表明：经预处理固硫灰可以应用于干粉砂浆中,且掺量为10%时效果最佳。固硫灰与粉煤灰等矿物掺合料复掺可以改善干粉砂浆性能。     

确定土壤背景值的Hazen概率法——以铜陵矿区Pb为例

本文选取已知土壤背景含量的铜陵矿区,基于Hazen概率曲线,探讨了土壤污染重金属元素Pb背景含量与污染叠加含量的区分方法.得到Pb元素的背景含量为28.5μg/g,与该区深层土壤样中Pb元素含量的平均值(34μg/g)比较接近.还得到了Pb元素污染叠加含量与背景含量的界线点51μg/g.基于Hazen概率曲线区分铜陵矿区土壤Pb元素背景含量与污染叠加含量的方法是有效的,有必要将该方法推广到土壤中其它重金属污染元素、其它地区作进一步研究.     

Strength and chloride resistance of blended Portland cement mortar containing palm oil fuel ash and fly ash

This paper presented a study on the strength and chloride resistance of mortars made with ternary blends of ordinary Portland cement (OPC), ground palm oil fuel ash (POA), and classified fly ash (FA). The mortar mixtures were made with Portland cement type I containing 0-40wt% FA and POA. FA and POA with 1wt%-3wt% retained on a sieve No.325 were used. The compressive strength and rapid chloride penetration depth of mortars were determined. The results reveal that the use of ternary blended cements produces ...     

Influence of fly ash on early-age cracking behavior of high-flowing concrete

The effects of quality and content of fly ash on the early-age cracking behavior of high-flowing concrete (HFC) were investigated. The early-age cracking behavior of the HFC was analyzed by combining the tests of evaporation capacity and electrical resistivity of the HFC. In these tests, a modified flat-type specimen was adopted. The results show that the HFC will have a lower evaporation capacity when it is mixed with fine fly ash, while it will have a higher evaporation capacity when grade III fly ash is used as mineral admixture. And the electrical resistivity rate of HFC reduces with the increase of the content of fly ash. A nonlinear relationship exists between the cracking time of HFC and the minimum electrical resistivity. The early-age cracking behavior of HFC with fly ash can be enhanced by appropriately increasing the fine particle content and MgO, K₂O, and SO₃ contents of fly ash. The optimal content of fly ash, which makes a satisfied early-age cracking behavior of HFC, is obtained. And when the content of fly ash exceeds a critical value, the early-age cracking behavior of HFC will rapidly decrease. Foundation item: Project(50478003) supported by the National Natural Science Foundation of China; Project(2002F007) supported by the Natural Science Foundation of Fujian Province, China     

Preparation and mechanical properties of polypropylene fiber reinforced calcined kaolin-fly ash based geopolymer

To improve the environmental benefits and solve the problems of large shrinkage and high brittleness, the partial replacement of calcined kaolin by fly ash as a raw material for geopolymer synthesis and the influences of polypropylene (PP) fiber on the mechanical properties and volume stability were investigated. The results show that compressive strength of the geopolymer containing 33.3%(mass fraction) fly ash by steam curing at 80 °C for 6 d is improved by 35.5%. The 3-day compressive strength, flexural strength and impacting energy of geopolymers containing 0.05%PP fiber increase by 67.8%, 36.1% and 6.25%, while the shrinkage and modulus of compressibility decrease by 38.6% and 31.3%, respectively. The results of scanning electron microscopy (SEM) and the appearances of crack growths confirm that PP fiber can offer a bridging effect over the harmful pores and defects and change the expanding ways of cracks, resulting in a great improvement of strength and toughness. Foundation item: Project(2006AA06Z225) supported by the National High-Tech Research and Development Program of China     

掺灰膨胀土的膨胀特性试验研究

通过生石灰对膨胀土的改性作用,在相同初始含水率的条件下,比较改性前后膨胀力、膨胀率的变化趋势,寻求最佳掺灰率;分析了膨胀力与初始含水率,膨胀率与初始含水率以及终止吸水量与初始含水率等关系.     

新型燃煤烟气汞吸附剂的评价研究

利用汞蒸气发生器产生的单质汞,与压缩空气组成模拟烟气,在吸附剂评价实验台上进行吸附剂脱汞实验,研究不同吸附剂对单质汞的脱除效率．实验结果表明,活性炭对汞的吸附效率在60％左右,未改性的燃煤飞灰吸附效率在10％～20％,改性后的燃煤飞灰比表面积有很大程度的提高,吸附效率可以达到25％,与活性炭吸附效率相比仍有不小的差距．     

高含硫气藏中元素硫沉积形态和微观分布研究

元素硫沉积是高含硫气藏开采过程中存在而又必须解决的难题之一.随着高含硫气藏储层压力不断下降,元素硫溶解度也不断下降,一旦元素硫溶解度低于元素硫含量,元素硫就会从地层中沉积下来.沉积的元素硫会堵塞地层孔隙,降低渗透率,严重影响气井产能.为了研究元素硫在地层中的沉积形态和沉积特征,利用自主设计的实验流程和实验方法,使TD5-1井高含硫气体通过岩芯,并降低压力让元素硫在岩芯中沉积下来,然后对沉积了元素硫的岩芯进行电镜扫描和能谱分析,首次得到了元素硫在岩芯中的沉积形态,即元素硫主要以膜状形式分布在岩芯孔隙壁面上.该研究结果为深入认识、掌握元素硫沉积规律以及指导高含硫气藏合理开发奠定了基础.     

碳酸根含量对碳酸羟基磷灰石形貌和热处理的影响分析

采用沉淀法制备了两种不同碳酸根〈CO3^2-）含量的纳米碳酸羟基磷灰石（nanosized carbonated hydroxyapatite,CHA）,研究了碳酸根含量对CHA晶体形貌、烧结和热稳定性的影响,用X射线衍射和透射电镜表征了样品的物相组成与形貌．结果表明：随着碳酸根含量的减小,CHA晶粒尺寸和长径比增加;CHA坯体的烧结温度和粉体的热稳定性与初始的碳酸根含量有关,含量越高,烧结温度越低,热稳定性越差．