Novel a‐Si:H TFT pixel circuit for electrically stable top‐anode light‐emitting AMOLEDs

Abstract— A novel pixel circuit for electrically stable AMOLEDs with an a‐Si:H TFT backplane and top‐anode organic light‐emitting diode is reported. The proposed pixel circuit is composed of five a‐Si:H TFTs, and it does not require any complicated drive ICs. The OLED current compensation for drive TFT threshold voltage variation has been verified using SPICE simulations.     

Current programming pixel circuit and data‐driver design for active‐matrix organic light‐emitting diodes

Abstract— We propose a new pixel design for active‐matrix organic light‐emitting diodes (AMOLEDs) employing five polycrystalline thin‐film transistors (poly‐Si TFTs) and one capacitor, which decreases the data current considerably in order to reduce the charging time compared with that of conventional current‐mirror structures. Also, the new pixel design compensates the threshold‐voltage degradation of OLEDs caused by continuous operation and the non‐uniformity of poly‐Si TFTs due to excimer‐laser annealing. The proposed pixel circuit was verified by SPICE simulation, based on measured TFT and OLED characteristics. We also propose current‐data‐driver circuitry that reduces the number of shift‐register signals for addressing the current data driver by one‐half.     

A new current‐mirror pixel circuit employing poly‐Si TFTs for active‐matrix organic light‐emitting‐diode displays

Abstract— A novel active‐matrix organic light‐emitting‐diode (AMOLED) display employing a new current‐mirror pixel circuit, which requires four‐poly‐Si TFTs and one‐capacitor and no additional signal lines, has been proposed and sucessfully fabricated. The experimental results show that a new current mirror can considerably compensate luminance non‐uniformity and scale down a data current more than a conventional current‐mirror circuit in order to reduce the pixel charging time and increase the minimum data current. Compared with a conventional two‐TFT pixel, the luminance non‐uniformity induced by the grain boundaries of poly‐Si TFTs can be decreased considerably from 41% to 9.1%.     

Fast voltage‐driving scheme for AMOLED displays based on internal feedback

Abstract— A new driving scheme for active‐matrix organic light‐emitting diodes (AMOLED) displays based on voltage programming is proposed. While conventional voltage drivers have a trade‐off between speed and accuracy, the new scheme is inherently fast and accurate. Based on the new driving scheme, a fast pixel circuit is designed using amorphous‐silicon (a‐Si) thin‐film transistors (TFTs). As the simulation results indicate, this pixel circuit can compensate the threshold‐voltage shift (VT shift) of the driver transistors. This pixel can be programmed in just 10 μsec, and it can compensate the threshold‐voltage shifts over 5 V with an error rate of less than 5% for a 1 ‐μA pixel current.     

Threshold‐voltage‐compensation methods for AMOLED pixel and analog buffer circuits

Abstract— New pixel‐circuit designs for active‐matrix organic light‐emitting diodes (AMOLEDs) and a new analog buffer circuit for the integrated data‐driver circuit of active‐matrix liquid‐crystal displays (AMLCDs) and AMOLEDs, based on low‐temperature polycrystalline‐silicon thin‐film transistors (LTPS‐TFTs), were proposed and verified by SPICE simulation and measured results. Threshold‐voltage‐compensation pixel circuits consisting of LTPS‐TFTs, an additional control signal line, and a storage capacitor were used to enhance display‐image uniformity. A diode‐connected concept is used to calibrate the threshold‐voltage variation of the driving TFT in an AMOLED pixel circuit. An active load is added and a calibration operation is applied to study the influences on the analog buffer circuit. The proposed circuits are shown to be capable of minimizing the variation from the device characteristics through the simulation and measured results.     

An AMOLED pixel circuit for high image quality of 1000 ppi mobile displays in AR and VR applications

In this paper, an active‐matrix organic light‐emitting diode pixel circuit is proposed to improve the image quality of 5.87‐in. mobile displays with 1000 ppi resolution in augmented and virtual reality applications. The proposed pixel circuit consisting of three thin‐film transistors (TFTs) and two capacitors (3T2C) employs a simultaneous emission driving method to reduce the number of TFTs and the emission current error caused by variations in threshold voltage (Vth) and subthreshold slope (SS) of the low‐temperature polycrystalline silicon TFTs. Using the simultaneous emission driving method, the compensation time is increased to 90 μs from 6.5 μs achieved in the conventional six TFTs and one capacitor (6T1C) pixel circuit. Consequently, the emission current error of the proposed 3T2C pixel circuit was reduced to ±3 least significant bit (LSB) from ±12 LSB at the 32nd gray level when the variations in both the Vth and SS are ±4σ. Moreover, both the crosstalk errors due to the parasitic capacitances between the adjacent pixel circuits and due to the leakage current were achieved to be less than ±1 LSB over the entire gray level. Therefore, the proposed pixel circuit is very suitable for active‐matrix organic light‐emitting diode displays requiring high image quality.     

Active‐matrix organic light‐emitting diode using inverse‐staggered poly‐Si TFTs with a center‐offset gated structure

Abstract— A low‐cost active‐matrix backplane using non‐laser polycrystalline silicon (poly‐Si) having inverse‐staggered TFTs with amorphous‐silicon (a‐Si) n⁺ contacts has been developed. The thin‐film transistors (TFTs) have a center‐offset gated structure to reduce the leakage current without scarifying the ON‐currents. The leakage current of the center‐offset TFTs at Vg = ?10 V is two orders of magnitude lower than those of the non‐offset TFTs. The center‐offset length of the TFTs was 3 μm for both the switching and driving TFTs. A 2.2‐in. QQVGA (1 60 × 1 20) active‐matrix organic light‐emitting‐diode (AMOLED) display was demonstrated using conventional 2T + 1C pixel circuits.     

An active‐matrix organic light‐emitting‐diode pixel circuit for the compensation of I × R voltage drop in power line

Abstract— A new voltage‐driving active‐matrix organic light‐emitting diode (AMOLED) pixel circuit is proposed to improve the display image‐quality of AMOLED displays. Because OLEDs are current‐driven devices, the I × R voltage drop in the power lines is evitable. Accordingly, the I × R voltage‐drop compensation scheme should be included in the pixel‐driving method when a voltage‐compensation method is used. The proposed pixel was designed for the compensation of an I × R voltage drop in the power lines as well as for the compensation of the threshold‐voltage non‐uniformity of low‐temperature polycrystalline‐silicon thin‐film transistors (LTPS TFTs). In order to verify the compensation ability of the proposed pixel, SPICE simulation was performed and compared with those of other conventional pixels. When the Vss voltage varies from 0 to 1 V, the drain current of the proposed pixel decreased by under 1% while that of conventional Vth compensation methods without Vss compensation decreased by over 60%. 2.2‐in. QCIF⁺ full‐color AMOLED displays, which employ the proposed pixel, have been also developed. It was verified by comparison of the display image quality with a conventional panel that our proposed panel successfully overcame the voltage‐drop problems in the power lines.     

Amorphous‐oxide TFT backplane for large‐sized AMOLED TVs

Abstract— Amorphous‐oxide thin‐film‐transistor (TFT) arrays have been developed as TFT backplanes for large‐sized active‐matrix organic light‐emitting‐diode (AMOLED) displays. An amorphous‐IGZO (indium gallium zinc oxide) bottom‐gate TFT with an etch‐stop layer (ESL) delivered excel lent electrical performance with a field‐effect mobility of 21 cm²/V‐sec, an on/off ratio of >10⁸, and a subthreshold slope (SS) of 0.29 V/dec. Also, a new pixel circuit for AMOLED displays based on amorphous‐oxide semiconductor TFTs is proposed. The circuit consists of four switching TFTs and one driving TFT. The circuit simulation results showed that the new pixel circuit has better performance than conventional threshold‐voltage (VTH) compensation pixel circuits, especially in the negative state. A full‐color 19‐in. AMOLED display with the new pixel circuit was fabricated, and the pixel circuit operation was verified in a 19‐in. AMOLED display. The AMOLED display with a‐IGZO TFT array is promising for large‐sized TV because a‐IGZO TFTs can provide a large‐sized backplane with excellent uniformity and device reliability.     

Characteristics and stability of improved re‐crystallized metal‐induced laterally crystallized polycrystalline‐silicon thin‐film transistors for display applications

Abstract— The performance of high‐temperature re‐crystallized (RC) metal‐induced laterally crystallized (MILC) polycrystalline‐silicon (poly‐Si) thin‐film transistors (TFT) have been improved by (1) patterning the active islands before MILC, (2) removing nickel‐containing residues using acid cleaning, (3) using heavily boron‐doped poly‐Si gates to achieve threshold voltage symmetry, and (4) double‐implanting n‐type source/drain junctions. A 30‐MHz driver circuit based on this improved technology was demonstrated. The reliability of optimized RC‐MILC poly‐Si TFTs has not been adversely affected by residual nickel‐containing contaminants in the TFT channel regions.     

Modeling of current—voltage characteristics for double‐gate a‐IGZO TFTs and its application to AMLCDs

Abstract— The equations for the transfer characteristics, subthreshold swing, and saturation voltage of double‐gate (DG) a‐IGZO TFTs, when the top‐ and bottom‐gate electrodes are connected together (synchronized), were developed. From these equations, it is found thatsynchronized DG a‐IGZO TFTs can be considered as conventional TFTs with a modified gate capacitance and threshold voltage. The developed models were compared with the top or bottom gate only bias conditions. The validity of the models is discussed by using the extracted TFT parameters for DG coplanar homojunction TFTs. Lastly, the new pixel circuit and layout based on a synchronized DG a‐IGZO TFT is introduced.     

A novel TFT‐OLED integration for OLED‐independent pixel programming in amorphous‐Si AMOLED pixels

Abstract— The direct voltage programming of active‐matrix organic light‐emitting‐diode (AMOLED) pixels with n‐channel amorphous‐Si (a‐Si) TFTs requires a contact between the driving TFT and the OLED cathode. Current processing constraints only permit connecting the driving TFT to the OLED anode. Here, a new “inverted” integration technique which makes the direct programming possible by connecting the driver n‐channel a‐Si TFT to the OLED cathode is demonstrated. As a result, the pixel drive current increases by an order of magnitude for the same data voltages and the pixel data voltage for turn‐on drops by several volts. In addition, the pixel drive current becomes independent of the OLED characteristics so that OLED aging does not affect the pixel current. Furthermore, the new integration technique is modified to allow substrate rotation during OLED evaporation to improve the pixel yield and uniformity. The new integration technique is important for realizing active‐matrix OLED displays with a‐Si technology and conventional bottom‐anode OLEDs.     

PECVD‐based nanocrystalline‐silicon TFT backplanes for large‐sized AMOLED displays

Abstract— A 14.1‐in. AMOLED display using nanocrystalline silicon (nc‐Si) TFTs has been developed. Nanocrystalline silicon was deposited using conventional 13.56‐MHz plasma‐enhanced chemical vapor deposition (PECVD). Detailed thin‐film characterization of nc‐Si films was followed by development of nc‐Si TFTs, which demonstrate a field‐effect mobility of about 0.6–1.0 cm²/V‐sec. The nc‐Si TFTs show no significant shift in threshold voltage when over 700 hours of constant current stress is applied, indicating a stable TFT backplane. The nc‐Si TFTs were successfully integrated into a 14.1‐in. AMOLED display. The display shows no significant current decrease in the driving TFT of the 2T‐1cap circuit because the TFTs are highly stable. In addition to the improved lifetime of AMOLED displays, the development of nc‐Si TFTs using a conventional 13.56‐MHz PECVD system offers considerable cost advantages over other laser and non‐laser polysilicon‐TFT technologies for large‐sized AMOLEDs.     

Digital‐to‐analog converter with gamma correction on glass substrate for TFT‐panel applications

Abstract— Low‐temperature polysilicon (LTPS) technology has a tendency towards integrating all circuits on glass substrate. However, the poly‐Si TFTs suffered poor uniformity with large variations in the device characteristics due to a narrow laser process window for producing large‐grained poly‐Si TFTs. The device variation is a serious problem for circuit realization on the LCD panel, so how to design reliable on‐panel circuits is a challenge for system‐on‐panel (SOP) applications. In this work, a 6‐bit R‐string digital‐to‐analog converter (DAC) with gamma correction on glass substrate for TFT‐panel applications is proposed. The proposed circuit, which is composed of a folded R‐string circuit, a segmented digital decoder, and reordering of the decoding circuit, has been designed and fabricated in a 3‐μm LTPS technology. The area of the new proposed DAC circuit is effectively reduced to about one‐sixth compared to that of the conventional circuit for the same LTPS process.     

Vt Compensated voltage‐data a‐Si TFT AMOLED pixel circuits

Abstract— Active‐matrix organic light‐emitting‐diode (AMOLED) displays are now entering the marketplace. The use of a thin‐film‐transistor (TFT) active matrix allows OLED displays to be larger in size, higher in resolutions and lower in power dissipation than is possible using a conventional passive matrix. A number of TFT active‐matrix pixel circuits have been developed for luminance control, while correcting for initial and electrically stressed TFT parameter variations. Previous circuits and driving methods are reviewed. A new driving method is presented in which the threshold‐voltage (V_t) compensation performance, along with various circuit improvements for amorphous‐silicon (a‐Si) TFT pixel circuits using voltage data, are discussed. This new driving method along with various circuit improvements is demonstrated in a state‐of‐the‐art 20‐in. a‐Si TFT AMOLED HDTV.     

A new a‐Si:H TFT pixel circuit employing data‐reflected negative‐bias annealing for a stable and uniform AMOLED

Abstract— A new a‐Si:H pixel circuit to reduce the VTH degradation of driving a‐Si:H thin‐film transistors (TFTs) by data‐reflected negative‐bias annealing (DRNBA) is presented. The new pixel circuit compensates VTH variation induced by non‐uniform degradation of each a‐Si:H pixel due to various electrical stress. The proposed pixel circuit was verified by SPICE simulations. Although the VTH of the driving a‐Si:H TFT varies from 2.5 to 3.0 and 3.5 V, the organic light‐emitting diode (OLED) current changes by only 1.5 and 2.8% in the emission period, respectively. During the negative‐bias annealing period, the negative VGS is applied to the driving TFT by using its own data signal. It is expected that the VTH shift of the driving TFT can be effectively reduced and the VTH shift can be compensated for in our new pixel circuit, which can contribute to a stable and uniform image from an a‐Si:H TFT active‐matrix OLED.     

High‐speed pixel circuits for large‐sized 3‐D AMOLED displays

Abstract— Large‐sized active‐matrix organic light‐emitting diode (AMOLED) displays require high‐frame‐rate driving technology to achieve high‐quality 3‐D images. However, higher‐frame‐rate driving decreases the time available for compensating Vth in the pixel circuit. Therefore, a new method needs to be developed to compensate the pixel circuit in a shorter time interval. In this work, image quality of a 14‐in. quarter full‐high‐definition (qFHD) AMOLED driven at a frame rate of over 240 Hz was investigated. It was found that image degradation is related to the time available for compensation of the driving TFT threshold voltage. To solve this problem, novel AMOLED pixel circuits for high‐speed operation are proposed to compensate threshold‐voltage variation at frame rates above 240 Hz. When Vth is varied over ±1.0 V, conventional pixel circuits showed current deviations of 22.8 and 39.8% at 240 and 480 Hz, respectively, while the new pixel circuits showed deviations of only 2.6 and 5.4%.     

An averaging pixel structure using microcrystalline‐silicon films prepared at high temperature for AMOLED displays

Abstract— A new voltage‐addressed pixel using a multiple drive distribution has been developed to improve, in a simple way, the brightness uniformity of active‐matrix organic light‐emitting‐diode (AMOLED) displays. Moreover, circuits were realized using microcrystalline‐silicon (μc‐Si) films prepared at 600°C using a standard low‐pressure CVD system. The developed p‐channel TFTs exhibit a field‐effect mobility close to 6 cm²/V‐sec. The experimental results show that the proposed spatial distribution of driving TFTs improves the uniformity of current levels, in contrast to the conventional two‐TFT pixel structure. Backplane performances have been compared using circuits based on μc‐Si and furnace‐annealed polysilicon materials. Finally, this technology has been used to make an AMOLED demonstration unit using a top‐emission OLED structure. Thus, by combining both an μc‐Si active‐layer and a current‐averaging driver, an unsophisticated solution is provided to solve the inter‐pixel non‐uniformity issue.     

Voltage‐programming method with transimpedance‐feedback technique for threshold voltage and mobility compensations in large‐area high‐resolution AMOLED displays

Abstract— A voltage‐programming method with transimpedance‐feedback control technique is proposed for compensating threshold voltage and mobility variations of driving thin‐film transistors (TFTs) in large‐area high‐resolution polycrystalline‐silicon (poly‐Si) active‐matrix organic light‐emitting‐diode (AMOLED) displays. Those electrical characteristic variations of TFTs throughout a large‐area high‐resolution panel result in picture‐quality non‐uniformity of AMOLED displays. The simulation and experimental results of the proposed method show that the maximum emission‐current error for 30‐in. full‐high‐definition television (HDTV) applications is less than 1.9% when the mobility variation and the threshold‐voltage variation are ±12.5% and ±0.3 V, respectively. The proposed method is the best programming method for large‐area high‐resolution AMOLEDs among the published methods.     

Clamped‐inverter circuit architecture for luminescent‐period‐control driving of active‐matrix OLED displays

Abstract— An innovative pixel‐driving technology for high‐performance active‐matrix OLED flat‐panel displays is described. Called “clamped‐inverter circuit architecture,” it uses luminescent‐period‐control driving to reduce the inter‐pixel non‐uniformity caused by the device‐to‐device variability of low‐temperature poly‐Si TFTs. A prototype full‐color display shows a luminous deviation of less than 1.6%, which corresponds to only the LSB‐error in 6‐bit gray‐scale.