天然的,物理和化学改性的面包果淀粉的功能特性

淀粉从面包果中分离出来,它通过氧化、乙酰化、热湿处理和退火作用而深度改性。研究了天然和改性淀粉的功能特性,近似分析表明,通过退火、氧化和乙酰化作用改性的淀粉比天然淀粉有较高的湿度,而通过热湿作用改性的淀粉有较低的湿度。除了天然淀粉和退火淀粉有相同的天然纤维含量(042％)之外,其它改性淀粉的天然纤维含量均降低。通过改性之后,蛋白质和脂肪含量也降低了。乙酰化、氧化和热处理作用提高了天然淀粉的膨胀力。     

Properties of enzyme modified corn, rice and tapioca starches

Corn, rice and tapioca starches were partially hydrolyzed by treating the starch dispersions with heat stable α-amylase. Dextrose equivalent (DE) of 8–12 was achieved by hydrolyzing the starch samples (10–20% w/v) for 30 min at 90 ± 2 °C. Scanning electron micrographs showed that starch granules had broken down to smaller particles. High performance liquid chromatography with refractive index detection indicated that oligosaccharides with broad molecular weight distributions are present in the reaction products. Hydrolyzed starch dispersions were analyzed for their rheological properties. The storage modulus values (G′) for 20% solid containing slurries were 7373 and 1470 Pa for untreated and enzyme treated samples, respectively, indicating a marked decrease in solid properties due to enzyme action. The complex viscosities (η^*) for native corn starch and hydrolyzed corn starch were 8243 and 1637 Pas, respectively, which indicate that the enzyme treatment decreases the overall resistance of the sample to flow such that the product can spread easily. Further 13C CP/MAS NMR and FTIR studies revealed the loss of ordered structures in the enzyme modified starches. Free flowing fat substitute in the form of fine powder was prepared by spray drying the hydrolyzed starch slurry.     

Structural characteristics and in vitro digestibility of Mango kernel starches (Mangifera indica L.)

Structural characteristics and digestibility of starches isolated from the kernels of two mango cultivars (Chausa and Kuppi) were studied and compared with those of a commercial normal corn starch. Mango kernel starches showed an A-type X-ray diffraction pattern, with relative crystallinities of 35.4% and 38.3%, respectively for Kuppi and Chausa cultivars. The structural characterisation obtained, using high performance size exclusion column chromatography connected to multi-angle laser light scattering and refractive index detectors (HPSEC-MALLS-RI), revealed that the mango kernel starches had lower molecular weight (M_w) and radius of gyration (R_g) of amylopectin and amylose compared to those of corn starch. The M_w of amylopectin for Chausa and Kuppi starches were 179 × 10⁶ and 140 × 10⁶ g/mol, respectively. The amounts of readily digestible starch (RDS) and slowly digestible starch (SDS) were lower for mango kernel starch than those of corn starch. Resistant starch (RS) contents in the mango kernel starches (75.6% and 80.0%, respectively) were substantially higher than those of corn starch (27.3%). The glycemic index (GI) values for mango kernel starches were 48.8 and 50.9 (for Chausa and Kuppi, respectively), whereas that of corn starch was 74.8, indicating that the mango kernel starch granules were highly resistant to digestion with significant contents of RS.     

湿热处理对不同晶型淀粉理化性质及消化性的影响

采用三种不同晶型淀粉即玉米淀粉(A型)、马铃薯淀粉(B型)、豌豆淀粉(C型)为原料,在水分含量为25%、温度120℃条件下湿热处理13 h,研究湿热处理对不同晶型淀粉的理化性质及消化性的影响。研究表明,与原淀粉相比,经湿热处理的三种淀粉的结晶结构均发生了改变,玉米淀粉由A型变为了A+V型,马铃薯淀粉和豌豆淀粉分别由B型和C型变为了A型;三种淀粉颗粒表面均出现了不同程度的破损;三种淀粉的部分颗粒的偏光十字的中心强度有所减弱;三种淀粉样品的糊化温度均升高,但A型和B型淀粉的焓值降低,而C型淀粉的焓值升高;三种淀粉的抗性组分含量均有所升高,抗消化性显著增强,其中C型淀粉变化最明显。     

THE FLOW PROPERTIES OF NATIVE, HEAT-MOISTURE TREATED, AND ANNEALED STARCHES FROM WHEAT, OAT, POTATO AND LENTIL

The effect of heat-moisture treatment (30% moisture, 100C, 16 h) and annealing (75 % moisture, 50C, 72 h) on the flow behavior of gelatinized starch pastes from wheat, oat, lentil and potato starches were studied at a concentration of 6% starch with a cone and plate viscometer (Wells Brookfield RVTDV II CP 200). The power law rheological model (σ=Kγⁿ) was used to describe the flow behavior of the above starch pastes. All native starches exhibited a non-Newtonian shear thinning behavior. A thixotropic loop was evident only in oat starches and native potato starch. Among native starches, the magnitude of the shear thinning index (n) followed the order: oat > wheat > lentil > potato, while the corresponding order for the consistency index (K) was: potato > lentil > wheat > oat. Heat-moisture treatment decreased the K value of all starches. On annealing, K decreased in wheat and lentil starches, but increased in potato and oat starches. Heat-moisture treatment and annealing increased the n value of wheat, lentil and potato starches, but decreased that of oat starch. In all starches, the modification to the flow behavior was more marked on heat-moisture treatment than on annealing.     

湿热处理对淀粉改性的研究进展

湿热处理是改性淀粉的一种新的物理方法。本文列举了不同种类淀粉的湿热处理条件，对湿热处理影响淀粉的理化性质如颗粒形貌、糊化性质、以及对酸和酶的敏感性等作了概述。最后阐述了湿热处理对淀粉作用的机理及发展。     

Effect of single and dual hydrothermal treatments on the crystalline structure,thermal properties,and nutritional fractions of pea,lentil, and navy bean starches

Pea, lentil and navy bean starches were annealed at 50 °C (70% moisture) for 24 h and heat-moisture treated at 120 °C (30% moisture) for 24 h. These starches were also modified by a combination of annealing (ANN) and heat-moisture treatment (HMT). The impact of single and dual modifications (ANN–HMT and HMT–ANN) on the crystalline structure, thermal properties, and the amounts of rapidly digestible starch (RDS), slowly digestible starch (SDS), and resistant starch (RS) were investigated. Birefringence remained unchanged on ANN but decreased on HMT. Granular swelling and amylose leaching decreased on ANN and HMT. Relative crystallinity, gelatinization enthalpy, and short-range order on the granule surface increased on ANN but decreased on HMT. Gelatinization transition temperatures increased on ANN and HMT. Gelatinization temperature range decreased and increased on ANN and HMT, respectively. ANN and HMT increased SDS and decreased RS levels in all starches. However, RDS levels increased on ANN and HMT in pea and lentil starches but decreased in navy bean starch. In gelatinized starches, ANN and HMT decreased RDS level and increased SDS and RS levels. Changes to crystalline structure, thermal properties and amounts of RDS, SDS, and RS were modified further on ANN–HMT and HMT–ANN.     

Hydrothermal treatments of rice starch for improvement of rice noodle quality

Two types of hydrothermal treated rice starches were prepared by annealing and heat-moisture treatment (HMT). Annealing of starch slurry was conducted at 55 °C for 24 h and HMT was applied in starch with 20 g/100 g moisture at 110 °C for 1.5 h, based on the optimization of the treatment conditions. The apparent changes on gelatinization, swelling, RVA paste viscosities and gel hardness of starch were observed. The study on 50% substitution of rice flour with untreated (UR), annealed (AR) or heat-moisture treated (HR) rice starches proved that the cooking and texture quality of rice noodle was substantially affected by the treatments. The composite noodles of flour and hydrothermal treated rice starches exhibited quality parameters which were closer to those of commercial noodles. The results revealed the possibility of utilizing these starches with low quality rice flour so as to produce noodles of acceptable quality. The study also inferred that characterization of RVA paste viscosities and gel texture of flour could become a practical method for predicting the quality of the derived noodle.     

Microstructural and physicochemical properties of heat-moisture treated waxy and normal starches

Starches from normal rice (21.72% amylose), waxy rice (1.64% amylose), normal corn (25.19% amylose), waxy corn (2.06% amylose), normal potato (28.97% amylose) and waxy potato (3.92% amylose) were heat-treated at 100 °C for 16 h at a moisture content of 25%. The effect of heat-moisture treatment (HMT) on morphology, structure, and physicochemical properties of those starches was investigated. The HMT did not change the size, shape, and surface characteristics of corn and potato starch granules, while surface change/partial gelatinization was found on the granules of rice starches. The X-ray diffraction pattern of normal and waxy potato starches was shifted from B- to C-type by HMT. The crystallinity of the starch samples, except waxy potato starch decreased on HMT. The viscosity profiles changed significantly with HMT. The treated starches, except the waxy potato starch, had higher pasting temperature and lower viscosity. The differences in viscosity values before and after HMT were more pronounced in normal starches than in waxy starches, whereas changes in the pasting temperature showed the reverse (waxy > normal). Shifts of the gelatinization temperature to higher values and gelatinization enthalpy to lower values as well as biphasic endotherms were found in treated starches. HMT increased enzyme digestibility of treated starches (except waxy corn starch); i.e., rapidly and slowly digestible starches increased, but resistant starch decreased. Although there was no absolute consistency on the data obtained from the three pairs of waxy and normal starches, in most cases the effects of HMT on normal starches were more pronounced than the corresponding waxy starches.     

湿热处理对玉米淀粉性质的影响

利用烘箱和高压灭菌锅对水分含量分别为10%、18%、25%、30% 的玉米淀粉在121℃处理5h,研究淀粉性质发生改变的情况。实验结果表明,玉米淀粉经湿热处理后,淀粉颗粒中心出现凹坑,颗粒结晶程度增加,淀粉的糊化温度上升,糊液黏度降低,在相同的处理条件下,利用高压灭菌锅处理对淀粉的性质影响更为显著。湿热处理对淀粉的性质产生明显影响。     

颗粒态绿豆抗性淀粉的制备及性质研究

以绿豆淀粉为原料,采用湿热处理制备颗粒态抗性淀粉,并研究其颗粒形貌、直链淀粉含量、溶胀度、黏度及结晶性质等。试验表明:淀粉经过湿热处理后,抗性淀粉含量显著提高;湿热处理淀粉仍保持完整的颗粒外观,属于颗粒态抗性淀粉,部分淀粉颗粒表面出现了裂纹和凹坑,偏光十字强度有所减弱;湿热处理淀粉的直链淀粉含量明显增加,而溶解度、膨胀度和峰值黏度下降,淀粉糊化变得困难;X-射线衍射图谱表明原淀粉和湿热处理淀粉都为"A"型结晶,且湿热处理淀粉在15.2°、17.4°、22.9°左右的衍射峰强度有所加强。     

小麦和甘薯抗性淀粉得率的工艺研究

采用酸变性和沸水浴的方法，对小麦和甘薯淀粉进行处理，以抗性淀粉得率作为评价指标，研究了在不同的淀粉乳浓度、盐酸用量、酸解时间、沸水浴时间、不同冷藏温度和时间条件下，小麦和甘薯淀粉糊化后形成抗性淀粉得率的变化情况，得到在不同条件下抗性淀粉得率受影响的趋势。     

Structural characterizations of waxy maize starch residue following in vitro pancreatin and amyloglucosidase synergistic hydrolysis

The objective of this work was to determine if in vitro digestion altered the molecular structure and slow digestion property of waxy maize starch. The Englyst testing on partially hydrolysis residual starches showed an increase of RDS accompanied a reduction of RS with increasing time of digestion, while SDS was almost constant. Scanning electron micrographs showed that the pattern of enzymatic hydrolysis was inside-out layer-by-layer digestion. A threefold decrease in the average molecular weight of starch components was observed after α-amylolysis for 120 min. There were increases in the onset temperature, peak temperature and ratio of absorbance 1047/1022 cm⁻¹, while the enthalpy of gelatinization, crystal structure, and crystallinity invaried. These changes suggest simultaneously enzymatic hydrolysis of both crystalline and amorphous regions of starch granule during in vitro digestion. SDS of starch residue also may consists of layered structure of amorphous and crystallite regions and located periphery of starch granules.     

湿热处理对玉米淀粉性质的影响

研究了湿热处理对不同直链淀粉含量的普通玉米淀粉?高直链玉米淀粉和蜡质玉米淀粉性质的影响。试验证明,经湿热处理后,三种玉米淀粉的颗粒形状都没有发生明显的变化,偏光十字也没有消失,但表面出现一些裂纹;湿热处理不会改变三种玉米淀粉的晶型,但经湿热处理后玉米淀粉的晶体结构变强,糊化温度提高,糊黏度降低。     

Effects of microwave heat-moisture treatment on properties of waxy and non-waxy rice starches

Waxy and non-waxy rice starches adjusted to 20% moisture (wet basis, w.b.) were heat-moisture treated in a microwave oven to determine the effects of the microwave heating characteristics on digestibility, pasting, and morphological properties of the heated starches. Microwave heating produced only minimal changes in digestibility as well as the physical characteristics of heated starches. Significant changes in viscosity properties after microwave heat treatment were observed for both waxy and non-waxy starches heat-treated in a microwave oven, relative to non-treated samples. Non-waxy starch heated in microwave oven showed an increase in breakdown viscosity from 29.8 RVU (non-treated starch) to 35.8 RVU after heating for 60 min. However, for waxy starch, breakdown viscosity decreased from 112.7 to 35.9 RVU after 60 min of microwave heat treatment, reflecting an increased stability of microwave heat-treated starch under cooking. The data obtained in this study indicate that there was much higher re-aggregation of starch granules in waxy starch after microwave heat treatment than occurred in non-waxy starch, suggesting a re-association of amylopectin branch chains in the heat-treated waxy starch.     

Chemical compositions,fine structure and physicochemical properties of kudzu (Pueraria lobata) starches from different regions

Three commercial kudzu starches from Vietnam, Japan and Korea were used to determine chemical compositions, isoflavone compounds, fine structure and physicochemical properties. The kudzu starch from Vietnam had polygonal granules, whereas the kudzu starches from Japan and Korea contained both polygonal and spherical granules. Total protein, lipid, ash and phosphorus contents present in these kudzu starches were less than 1% (starch basis). The kudzu starch from Vietnam and Korea contained both daidzein and daidzin, whereas the kudzu starch from Japan had only daidzein. These starches had similar actual amylose contents (22.2–22.9%). However, λ_max, blue value and apparent amylose contents of the kudzu starch from Vietnam were lower than those from Japan and Korea. Amylose molecules of the kudzu starch from Vietnam had the largest average degree of polymerization (DP_n) and number of chains (NC), followed by the kudzu starches from Japan and Korea. Amylopectin molecules of the kudzu starch from Vietnam also had the largest DP_n and NC, followed by the kudzu starches from Korea and Japan. X-ray diffraction patterns of the kudzu starches from Vietnam, Japan and Korea were A-type, C-type and B-type, respectively. The kudzu starch from Vietnam was found to have the specific characteristics such as significantly high gelatinization temperature, transition enthalpy and degree of crystallinity as compared to the kudzu starch from Korea and Japan.     

Effect of heat-moisture treatment on the formation and physicochemical properties of resistant starch from mung bean (Phaseolus radiatus) starch

Mung bean starch was subjected to a range of heat-moisture treatments (HMT) based on different moisture contents (15%, 20%, 25%, 30%, and 35%) all heated at 120 °C for 12 h. The impact on the yields of resistant starch (RS), and the microstructure, physicochemical and functional properties of RS was investigated. Compared to raw starch, the RS content of HMT starch increased significantly, with the starch treated at 20% moisture having the highest RS content. After HMT, birefringence remained at the periphery of the granules and was absent at the center of some granules. The shape and integrity of HMT starch granules did not change but concavity was observed under scanning electronic microscopy. Apparent amylose contents of HMT starch increased and the HMT starch was dominated by high molecular weight fraction. Both the native and HMT starches showed A-type X-ray diffraction pattern. Relative crystallinity increased after HMT. The gelatinization temperatures (To, Tp, and Tc), gelatinization temperature range (Tc–To) and enthalpies of gelatinization (ΔH) increased significantly in HMT starch compared to native starch. The solubility increased but swelling power decreased in HMT starches. This study clearly shows that the HMT exhibited thermal stability and resistance to enzymatic hydrolysis owing to stronger interactions of starch chains in granule.     

Development of oxidised and heat-moisture treated potato starch film

This study investigated the effects of sodium hypochlorite oxidation and a heat-moisture treatment of potato starch on the physicochemical, pasting and textural properties of potato starches in addition to the water vapour permeability (WVP) and mechanical properties of potato starch films produced from these starches. The carbonyl contents, carboxyl contents, swelling power, solubility, pasting properties and gel texture of the native, oxidised and heat-moisture treated (HMT) starches were evaluated. The films made of native, oxidised and HMT starches were characterised by thickness, water solubility, colour, opacity, mechanical properties and WVP. The oxidised and HMT starches had lower viscosity and swelling power compared to the native starch. The films produced from oxidised potato starch had decreased solubility, elongation and WVP values in addition to increased tensile strength compared to the native starch films. The HMT starch increased the tensile strength and WVP of the starch films compared to the native starch.     

Physicochemical,structural, and digestibility properties of enzymatic modified plantain and mango starches

The effect of two enzymatic treatments (increasing the branch density of starch and shortening of AP and amylose chains) on the fraction of slowly digestible starch (SDS) and resistant starch (RS) of plantain (Musa paradisiaca L.) and mango (Mangifera indica L.) starches was investigated. The enzymatic modifications were carried out using β‐amylase (β‐AMY) and β‐amylase‐transglucosidase (β‐AMY‐TGs), in gelatinized starches. Plantain starch showed an increase from 10.9 to 18.5% of SDS, when it was modified by β‐AMY‐TGs, while the treatment with β‐AMY alone showed reduction from 10.9 to 7.1% in SDS. RS content increased with both treatments. On the other hand, mango starch showed an increase in SDS from 6.3 to 22.3% using β‐AMY treatment and from 6.3 to 11.7% using β‐AMY‐TGs treatment. The latter treatment also increased RS content. The enzyme modified starches showed a reduction in the values of molar mass and gyration radius compared with the native starch. The content of short chains of AP, particularly in the DP range 5–12, increased, the percentage of crystallinity decreased in treated starches, and ¹H NMR spectra showed a significant increase of α‐(1 → 6) linkages in the starches modified with β‐AMY‐TGs. These characteristics were related to an increase in the slow and resistant digestion properties of plantain and mango starches.     

Influence of hydroxypropylation on retrogradation properties of native,defatted and heat-moisture treated potato starches

Recent studies have shown that defatting and heat-moisture treatment cause structural changes within the amorphous and crystalline regions of potato starch. Furthermore, the alkaline reagents (NaOH and Na₂SO₄) used during hydroxypropylation has been shown to cause structural changes within the amorphous and crystalline regions of native, defatted and heat-moisture treated starches. In this study, we have compared (using different techniques) the retrogradation properties of potato starch before and after physical (defatting and heat-moisture treatment), and chemical (alkaline treatment and hydroxypropylation) modification. Turbidity measurements showed that changes in turbidity during storage (4°C for 24 h and then at 40°C for 29 days) of native, defatted and heat-moisture treated gelatinized starch pastes were influenced by the interplay of two factors: (1) interaction between leached starch components (amylose–amylose, amylose–amylopectin, amylose–amylopectin), and (2) interaction between granule remnants and leached amylose and amylopectin. In alkali treated gelatinized native, defatted and heat-moisture treated starch pastes, turbidity changes on storage was influenced by aggregation of granule remnants. Hydroxypropylation decreased the rate and extent of increase in turbidity during storage of native, defatted and heat-moisture treated starches. The change in turbidity during storage of hydroxypropylated starch pastes was influenced by the interplay between: (1) steric effects imposed by hydroxypropyl groups on chain aggregation, (2) aggregation between small granule remnants, and (3) settling of large granule remnants beneath the path of the spectrophotometer beam. Stored gelatinized pastes of native, defatted and heat-moisture treated starches gave a `B' type X-ray pattern. A similar pattern was also observed after alkaline treatment, and hydroxypropylation. However, the X-ray intensity of the strong reflection at 5.2 Å decreased after alkaline treatment and hydroxypropylation. The retrogradation endotherm (monitored by differential scanning calorimetry) occurred after 2 days storage in native, defatted and heat-moisture treated starches. A similar trend was also observed after alkaline treatment. However, the retrogradation endotherm appeared only after 7 days in hydroxypropylated starches. The enthalpy of retrogradation in all starches decreased on alkaline treatment and hydroxypropylation.