输煤皮带热硫化胶接工艺

通过江苏徐州发电有限公司多年来对输煤皮带热硫化胶接的摸索与实践,对胶接工艺进行分析与总结,介绍了胶带接头尺寸的确定、硫化胶接的程序、接头热硫化工艺程序及硫化三要素,提出了皮带硫化胶接中的有关质量要求、需注意的问题及建议。     

Deep‐fat frying under moderate vacuum of potato cylinders

This study evaluates parameters relating to the mass transfer during the frying of potato cylinders at different temperatures (100, 120 and 140 °C) and moderate vacuum (around 25 kPa). In all cases, there is a linear relation between water loss and fat uptake. The parameters relating to the textural and structural modifications show less marked changes in vacuum fried products compared to those fried under atmospheric pressure. The maximum penetration force reaches 30%–40% of the initial hardness in vacuum frying and 10% for atmospheric pressure frying; starch gelatinization and pectin methylesterase enzyme activity reduce more quickly under atmospheric pressure, although after 240 s both values are negligible. The scanning electron microscopy images verify that the surface of potato cylinders fried under vacuum or atmospheric pressure are completely different as a result of the steam being released at different temperatures.     

MODEL APPLICATION: HYDRATION AND GELATINIZATION DURING RICE PARBOILING

The rate of water absorption of a local rough rice variety at temperatures below and above the corresponding gelatinization temperature was investigated. A mathematical model that describes water diffusion and gelatinization within the grain, was used to simulate rice parboiling. The data were processed using a nonlinear regression procedure to calculate the diffusion coefficients and reaction rate constants in the temperature range 35-95°C. Both coefficients follow an Arrhenius temperature dependency with a break point at 77°C, where rapid gelatinization of rice begins. From the comparison between the activation energies for diffusion and reaction it is concluded that the parboiling process is limited by the reaction of starch with water below 77°C and by diffusion of water above 77°C.     

微波处理对稻米酶活力及品质的影响

以２种粳米品种为对象，研究了微波处理对稻米酶活力，理化性质及食用品质的影响。结果表明稻米经微波处理后脱支酶及α－淀粉酶活力明显下降；米饭吸水率、米汤ｐＨ值及碘蓝值、β－淀粉酶活力和不溶性直链淀粉含量略有下降；糊化温度、最高粘度、最终粘度、破损值、胶凝值及可溶性直链淀粉含量略有升高；而总淀粉及全部直链淀粉含量则变化很小。     

Changes in Specific Heat of Corn Starch Due to Gelatinization

Differential scanning calorimetry (DSC) was used to measure apparent specific heat and heat of gelatinization for corn starch at a 13.4 to 79.1% moisture and 30°C to 100°C. Apparent specific heat of granular and heated starch was determined as a function of moisture content, temperature, and gelatinization. Effect of gelatinization was maximum at 42.3% moisture (wet basis) where the ratio of starch/water caused the largest differences in apparent specific heats. The largest difference corresponded to a degree of gelatinization of 0.429. A model was developed to predict apparent specific heats and provided values with a ±2.57% standard error (compared to experimental values) for heated starch with partial gelatinization over the range from 13.4 to 79.1% moisture.     

冷冻调理马铃薯饼加工技术的探讨

对马铃薯的预糊化实验结果揭示,在各种加热方法中,马铃薯经蒸煮25min后的糊化效果最好.正交试验结果表明,奶粉含量和黄油含量对冷冻调理马铃薯饼的感官指标有高度显著的影响.对冷冻调理马铃薯饼的油脂的测试结果显示,未经油炸的马铃薯饼的脂肪含量为4.24%,而经过油炸后的马铃薯饼的脂肪含量为11.18%.经过一个月的冻藏后,未经油炸的冷冻调理马铃薯饼的油脂的过氧化值为1.94%,而经过油炸的冷冻调理马铃薯饼的油脂的过氧化值为7.79%.     

Dielectric properties of Indian Basmati rice flour slurry

Dielectric properties of Indian Basmati rice samples (dry ground flour and wet aqueous slurry) were measured over the frequency range 500–2500 MHz. Temperature dependence of dielectric properties of rice flour slurries (20, 30 and 50 g flour per 100 g water yielding approximately 1:5, 1:3 and 1:2 flour to water ratio) were studied between 30 and 80 °C. Results indicated that dielectric constants (ε′) generally did not vary with frequency while the loss factor (ε″) showed an increasing trend. A sharp change in dielectric parameters were noted above 70 °C attributable to rice starch gelatinization, an observation confirmed later by differential scanning calorimetry. An increase in flour slurry concentration systematically reduced ε′ during the entire frequency range while variations in ε″ values were mixed. Addition of 1% salt markedly increased ε″ of slurries whereas butter resulted in significant reduction in ε′ values. Rice flour slurry containing both salt and butter exhibited intermediate values of dielectric properties. Both ε′ and ε″ data of rice slurries generally fitted a 2nd order polynomial relationship with temperature. These results suggest that dielectric measurements could be used to study frequency, concentration, ingredient and temperature dependent changes in starch–water systems during heating.     

不同品种鹰嘴豆淀粉糊与凝胶特性研究

以不同品种的鹰嘴豆Kabuli和Desi为原料,采用快速黏度仪、质构仪和流变仪研究淀粉糊与凝胶特性的差异。研究表明:Kabuli淀粉在糊化过程中的峰值、谷值、最终黏度等特征值均高于Desi淀粉,而降落值、回值及成糊温度却低于Desi淀粉。Kabuli淀粉的品质优于Desi淀粉,但这2种鹰嘴豆淀粉糊的糊丝均属于短糊系列。在不同热过程中Desi淀粉形成凝胶速度快,强度大;Kabuli淀粉的凝胶强度随温度的变化是可逆的。Kabuli淀粉凝胶破裂强度、弹性模量均小于Desi淀粉凝胶。     

全麦粉的添加对油馕面团品质的影响

考察添加不同比例的全麦粉,对油馕面团粉质特性、拉伸性、糊化特性、混合粉溶剂保留特性、面团水分分布和面团面筋蛋白二级结构的影响。结果表明,随着全麦粉含量的增加面团加工性质变差,面团吸水率由65.18%增加至最大值80.30%,面团形成时间从4.13 min增加到最大值5.34 min;面团的峰值黏度、谷值黏度、回生值和衰减值呈下降趋势,而糊化温度则不断提高;拉伸能量由87 cm2降低至30 cm2,延展度由156 mm降低至92 mm,拉伸阻力由302 EU降低至242 EU。当全麦粉完全取代精粉时与精粉组相比（全麦粉取代率为0%）,混合粉的碳酸钠、蔗糖和水溶剂保留率分别增加了20.56%、18.69%和34.94%,而乳酸溶剂保留率则降低23.47%;核磁结果显示,面团中水分分布变化情况为A21/A2升高,A22/A2和A23/A2下降;傅里叶变换红外光谱仪测定结果显示,面筋蛋白结构中α-螺旋和β-折叠的总相对含量由68.57%下降为50.89%,无规卷曲相对含量增加了31.5%,稳定的二级结构下降、不稳定的二级结构相对含量上升,导致面筋蛋白结构变差。     

马铃薯用作啤酒辅料的糊化工艺研究

研究了马铃薯用作啤酒辅料的最佳糊化工艺。结果表明马铃薯辅料的最佳糊化条件为:1∶5的料水比,6U/g马铃薯粉的耐高温a-淀粉酶添加量,糊化温度85℃,糊化时间25min。添加马铃薯辅料所制得的麦汁符合糖化麦汁的要求,其中高含量的氨基酸是其显著特征。