高性能膨胀剂(CMA)的研究与生产

综合目前国内膨胀剂领域的发展方向和借鉴以往研究成果，采用CaO（钙质熟料）、钙矾石、MgO三个膨胀源的相互作用，三者膨胀适当组合，取长补短，以获得更适宜的膨胀量和膨胀发挥，使膨胀曲线更趋合理。研究了不同掺量不同活性钙质熟料对CMA膨胀剂性能的影响，提出了制备钙质熟料的理化指标，并将CMA与传统膨胀剂的性能进行了对比。     

镍基高温合金真空感应熔炼脱氮的研究

研究了采用CaO坩埚真空感应熔炼镍基高温合金过程中的脱氮行为.试验表明在精炼过程中加Al对脱氮有促进作用;加Ti则对脱氮有明显不利影响;提高熔炼时的真空度是促进脱氮的有力措施.     

The low-temperature oxidation of calcium by water vapor

The oxidation kinetics of calcium in water vapor have been studied over the temperature range 25–300°C. There is a change in the form of the oxidation kinetics with temperature, from essentially linear at temperatures below 150°C to logarithmic at 300°C. This is coupled with a change in the manner of growth of the oxide layer as well as the chemical composition of the reaction product. In addition, the oxidation rate decreases with temperature, reaching a minimum at about 150°C. At temperatures below 150°C oxidation appears to be a result of the formation of cracks or fissures in the oxide film. Above 150°C no single oxidation mechanism can be deduced.     

Molecular dynamics of structural properties of molten CaO-SiO2 with varying composition

1　ＩＮＴＲＯＤＵＣＴＩＯＮＴｈｅｓｔｕｄｙｏｆｍｏｌｔｅｎｓｔｒｕｃｔｕｒｅｏｆＣａＯ ＳｉＯ2 ,ｗｈｉｃｈａｃｔａｓｔｈｅｂａｓｉｃｆａｃｔｏｒｉｎｆｌｕｅｎｃｉｎｇｔｈｅｐｈｙｓｉｃａｌａｎｄｃｈｅｍｉｃａｌｐｒｏｐｅｒｔｉｅｓｏｆｔｈｅｓｉｌｉｃａｔ     

添加剂CaO对含金、银硫精矿氧化焙烧过程的影响

云南某含金、银硫精矿硫品位 44.24%,金、银品位分别为 3.07g/t、36.3g/t,金主要以裸露金的形式存在,银主要以硫化银和硫化物包裹银的形式存在。氧化焙烧预处理后,金、银浸出率分别为 79.66%、68.13%,高温下氧化铁会出现熔融状态,对金、银进行二次包裹。加入焙烧添加剂 CaO,金浸出率提高至86.56%,银浸出率提高至 68.43%。CaO 与 Fe2O3、SiO2 的亲和力大于 ZnO,焙烧过程加入 CaO 与 ZnO·SiO2、PbO·SiO2 与 FeO·SiO2 反应,形成 CaO·SiO2,阻碍致密 ZnO·SiO2、PbO·SiO2 和 FeO·SiO2 形成,减少其对金、银的包裹,焙砂硅酸盐包裹金由 0.52g/t 降低至 0.13g/t。     

残留CO2对石灰在转炉初渣中溶解的影响

 在转炉炼钢过程中,石灰快速溶解对转炉高效脱磷具有十分重要的意义,石灰溶解过程中熔渣/石灰界面处形成的2CaO·SiO₂产物层被认为是阻碍石灰溶解的关键因素。制备了具有两种不同CO₂含量的部分煅烧石灰石,采用浸泡法研究了部分煅烧石灰石在转炉初渣中的溶解行为,并与纯石灰、石灰石的溶解行为进行比较。结果表明,石灰石溶解时在液态熔渣中CaO的传质系数为石灰的2.1倍,残留CO₂质量分数为10%的部分煅烧石灰石的传质系数高达石灰石的6.7倍。在CO₂质量分数为0～43.5%时,石灰的溶解速率先增大后减小。石灰溶解过程中形成的2CaO·SiO₂层严重阻碍了FeO_x的扩散,从而减缓了石灰的溶解。与石灰不同,石灰石分解产生的CO₂能够破坏2CaO·SiO₂层并破坏自身结构,有利于熔渣的渗透,这也适用于残留CO₂的部分煅烧石灰石。制备纯石灰的过程中为了确保石灰芯部完全煅烧,因此极易导致石灰外表面发生过烧,而制备部分煅烧石灰石能在一定程度上解决表面过烧的问题。此外,与石灰石相比,部分煅烧石灰石由于表面是石灰外壳,溶解初期其表面附近的炉渣温降相对更低,能够避免溶解初期出现停滞阶段。在转炉富余热量有限的情况下,部分煅烧石灰石的石灰替换比高于石灰石,这取决于部分煅烧石灰石中的CO₂残留量。     

Li2O对CaO基钢包渣系脱磷能力影响的热力学研究

渣金平衡实验表明Li2 O替代CaO基钢包渣系中等量CaO使渣系磷酸盐容量Cp提高。在此基础上进行钢液脱磷的工艺性实验 ,研究了Li2 O含量、渣系碱度及氧化性对渣系脱磷能力的影响 ,并给出了控制转炉钢液在钢包中回磷及钢包渣脱磷的渣系。     

含CaO陶瓷结合剂强度的研究

本文对含CaO陶瓷结合剂的强度影响机理进行了进一步的研究。研究结果表明,含CaO结合剂的强度与结合剂的网络结构参数Y有关。CaO作为网络改变体对网络结构的破坏作用可能是使含CaO陶瓷结合剂强度降低的一个主要原因。     

Reaction process of monazite and bastnaesite mixed rare earth minerals calcined by CaO-NaCl-CaCl2

The decomposition reactions of monazite and bastnaesite mixed rare earth minerals calcined by CaO-NaCl-CaCl2 were studied by means of TG-DTA and XRD. The results show that the process of the minerals decomposed by CaO involves two steps. The first step occurs in the temperature range of 425-540 ℃, and the main reactions are bastnaesite decomposition, i.e. REOF reacts with CaO to produce RE2O3 and CaF2, and Ce2O3 is oxidized to CeO2. During this step, CaCO3 is formed at about 500 ℃. The second step takes place in the temperature range of 610-700 ℃, and the reactions are monazite decomposition into RE2O3, Ca5F（PO4）3 and Ca3（PO4）2 by CaO and CaF2. In this process, the decomposition ability is improved because CaO from CaCO3 decomposing has high chemical activity. In calcining process, the new formed Ca5F（PO4）3 restrains fluorine that can escape in form of gaseous compound. The decomposition ratio of the mixed rare earth minerals reaches 90.8% at 700 ℃.     

Synthesis and luminescence properties of red phosphor CaO: Eu3+

Ca(NO₃)₂·4H₂O, Eu(NO₃)₃ and H₂C₂O₄·2H₂O were adopted to synthesize CaO: Eu³⁺ with the chemical co-precipitation method, and the effects of the calcination temperature and Eu³⁺ doping concentration on the phosphor structure and its luminescent properties were investigated by TG-SDTA, XRD, and PL-PLE. The results confirm that the Eu³⁺ ions as luminescent centers substitutes Ca²⁺ sites without changing the crystal structure of cubic CaO. The optimum calcination temperature and the optimum concentration of Eu³⁺ are 1 100 ° and 1 mol%, respectively, under which the best crystallinity and highest PL intensity appeared. The maximum emission wavelength is 592 nm (⁵D₀→⁷F₁) which is excited by xenon lamp with the wavelength of 200–280 nm, indicating that the Eu³⁺ ion mainly locates in the symmetric position (O_h) in the crystal lattice of CaO. Funded by the Science and Technology Bureau of Sichun Province(No. 2006J13-059) and Education Bureau of Sichun Province (No. 2006A094)