锅炉二次风道流动特性的模拟优化

以武汉武锅能源工程有限公司设计的二次风道为对象,运用数值模拟的方法考查了改造前后二次风道各出口空气的速度分布和质量流量分配情况。结果表明,通过布置弧形挡板,风道出口速度的均匀性显著提升,最大变异系数Cv由29%下降到9%,而且还避免了因风速不均引起的烧边现象。此外,改进后风道各出口空气的流量分配非常接近理想工况,与理想工况的偏差从9.9%缩小到2.1%。     

电磁搅拌对大圆坯结晶器冶金行为影响的探讨

 为了探究结晶器电磁搅拌(M EMS)对大圆坯结晶器内综合冶金行为的影响。以大断面圆坯连铸结晶器冶金行为为研究对象，基于电磁热流体与凝固传输理论建立三维耦合数值模型。揭示大圆坯连铸常用五孔水口浇注条件下结晶器内电磁场、流场、传热与凝固等综合冶金行为，提出电磁搅拌对结晶器冶金性能影响的多参量评价方法。以中碳铬钼齿轮钢650 mm大圆坯连铸为例，指出结晶器电磁搅拌存在最佳搅拌电流，可获得相对较好的综合冶金效果。具体表现为弯月面保持一定的切向速度和过热度，有利于保护渣的熔化和夹杂物的上浮去除；液面波动幅度在控制范围内，可避免卷渣、改善表面质量；结晶器内钢液过热得到有效耗散，有利于等轴晶形核改善铸坯内部质量；侧孔出流钢液速度得到有效控制，可抑制注流对初凝坯壳的冲刷，提高了初生坯壳生长的均匀性。此外，电磁搅拌产生的水平旋流强度也可得到有效控制，有利于避免常见的皮下白亮带现象。     

12000t/d水泥熟料生产线三次风管的优化改造*

水泥熟料生产过程中三次风管对分解炉和回转窑等热工设备的稳定运行起着重要作用。三次风管的用风和通风合理性,直接影响分解炉内煤粉的燃烧、碳酸盐在分解炉内的分解,间接影响回转窑内通风量和熟料在窑内的烧结。本文通过热工标定分析W工厂12000t/d水泥熟料生产线三次风管存在的问题,通过数据计算和对比分析,提出三次风管优化改造方案。     

Flame characteristics of premixed H2-air mixtures explosion venting in a spherical container through a duct

The explosion venting duct can effectively reduce the hazard degree of a gas explosion and conduct the venting energy to the safe area. To investigate the flame quantitative propagation law of explosion venting with a duct, the effects of hydrogen fraction and explosion venting duct length on jet flame propagation characteristics of premixed H₂-air mixtures were analyzed through experiment and simulation. The experiment results under initial conditions of room temperature and 1 atm show that when hydrogen fraction was high enough, part of the unburned hydrogen was mixed with air again to reach an ignitable concentration, resulting in the secondary combustion was easier produced and the duration of the secondary flame increased. With the increase of venting duct length, the flame front distance and propagation velocity increased. Meanwhile, the spatial distribution of pressure field and temperature field, and the propagation process and mechanism of the flame venting with a duct were analyzed using FLUENT software. The variation of the pressure wave and the pressure reflection oscillation law in the explosion venting duct was captured. Therefore, in the industrial explosion venting design with a duct, the hazard caused by the coupling of venting pressure and venting flame under different fractions should be considered comprehensively.     

2 000 t/d水泥生产线烧成系统技术改造

为了解决烧成系统不稳定，操作控制困难，对煤质的适应性差，存在安全、环保隐患，系统能耗高等问题，在保留原预热器框架不变的情况下，加大了C1旋风筒上部直筒段及涡壳，重新设置了C2、C3、C4旋风筒导流板，重新设计了C5旋风筒涡壳，并改造了相应的连接风管和下料管，更换了锁风翻板阀和撒料箱。同时将带流化床的管道式离线分解炉改为在线喷旋管道式分解炉，并对三次风管进行了改造，三次风从分解炉锥部单股旋切引入。本次技术改造实现了原定的各项技改目标，取得了良好的节能降耗效果。     

大规格圆棒用滚动导卫开度调节系统的改进

针对大规格圆棒生产用滚动导卫在轧制过程中导辊开度不能保持在设定值，影响产品质量及生产顺行的问题，通过对该类型导卫开度调节装置的工作原理及结构分析，明确了结构设计及选用材质与使用工况不匹配是问题产生的主要原因。为此，对调节装置进行了设计优化，改进后的导卫在线时间显著提高。     

45钢圆钢热顶锻开裂原因分析及改进措施

针对福建省三钢集团有限责任公司棒材厂45钢圆钢热顶锻出现的爆裂、斜向开裂、4角纵向通长开裂、纵向断续微裂4种开裂形式，从表面质量、组织、夹杂物、断口形貌等方面分析了其产生原因。结果表明，钢中存在粗大夹杂物是产生爆裂的主要原因；母材塑性不足是斜向开裂的主要原因；孔型设计不合理带来的皱褶缺陷引起了4角纵向通长开裂；除鳞不净，氧化铁皮压入导致了纵向断续微裂的产生。为此，提出了提高冶炼质量、改进化学成分、调整高压水除鳞工艺、优化孔型设计等措施，显著提高了其热顶锻合格率。     

基于特征建模的TDD系统大气波导干扰控制体系研究

大气波导干扰是特定气象条件下发生的时分双工（time-division duplex，TDD）系统内干扰，是TDD移动通信系统大规模组网面临的顽疾。在总结分析大气波导干扰成因和分类等的基础上，对大气波导干扰进行建模和表征，验证了海量干扰源在时域和频域的功率集总特征，并结合大量4G/5G现网实测数据给出了典型条件下内陆波导和海面波导的量化干扰信号传播模型，对于干扰的预测和预防具有重要意义。基于干扰特征，给出了TDD系统预防大气波导干扰的帧结构与组网的4项设计原则，5G现网数据表明干扰控制方案有效，上行干扰下降10 dB以上，相关原则对于6G系统的设计也具有指导意义。     

Ontogeny of the testicular excurrent duct system of male Japanese quail (Coturnix japonica): A histological,ultrastructural, and histometric study

The testicular excurrent duct system undergoes several physiological and morphological changes during the reproductive stage or breeding season in mammals, birds, and reptiles. Studies on normal age-related histomorphological changes in the excurrent duct system of Japanese quails (Coturnix japonica) remain unreported, despite the extensive use of this bird as an avian model in research studies. The current study investigated the histological, ultrastructural, and histometric changes in the testicular excurrent duct system of the Japanese quail during three reproductive stages, namely prepubertal, pubertal, and adult. Simple squamous to low cuboidal cells formed the epithelia of the rete testis in prepubertal and pubertal birds, while in adult birds the lining was low cuboidal to cuboidal. In pubertal and adult birds, the nonciliated Type I epithelial cells of the proximal efferent duct displayed a subapical endocytotic apparatus comprising coated pits, coated apical tubules, and endosomes. There was a significant increase (p ≤ .001) in epithelial heights of all ducts of the excurrent duct system in the mature, sexually active, adult birds when compared to the other age groups. The luminal and tubular diameters, and the cross-sectional areas of efferent ducts and the epididymal duct unit increased significantly (p ≤ .001) with age. It is concluded that the morphology and morphometry of the excurrent ducts of the testis of the Japanese quail change as birds mature.     

用相对灰色关联分析法综合评价金刚石钻头

根据TOPSIS法原理，提出一种同时考虑“理想方案”和“负理想方案”的金刚石钻头综合评价灰色关联分析法。结合φ60mm绳索取心金刚石钻头评价，说明了该方法的具体应用，并与用其它方法评价的的结果进行了对比。